1. PRODUCT IDENTIFICATION
|Product Name :||Oberon G30|
|UN Proper Shipping Name :||None allocated|
|Other Names :||None listed|
|Product Use :||The High Speed Bearings & Electric Motors Grease|
|CHEMTREC, 24-HOUR EMERGENCY TELEPHONE NUMBER|
|1-800-424-9300 (Toll-free)||For United States and Canada|
|1-703-527-3887||In the event of an incident occurring outside United States and Canada|
2. HAZARDS INDENTIFICATION
|Exposure to vapors generated at high temperatures, may cause respiratory irritation. For further information, please refer to Section 11.|
3. COMPOSITION/INFORMATION ON INGREDIENTS
|Name||EC No.||CAS No.||Content||Symbol||R-Phrases|
Residual oils (petroleum,) solvent
|Distillates (petroleum), solvent-refined Heavy paraffinic||265-090-8||64741-88-4||70-100 %||-|
Composition Comments Refer to Section 8 for exposure limits on ingredients.
4. FIRST AID MEASURES
Move the exposed person to fresh air at
once. For breathing difficulties oxygen could be necessary. Get medical
attention if any discomfort continues.
DO NOT INDUCE VOMITING! Get medical attention immediately!
Remove contaminated clothing. Wash skin thoroughly with soap and water. Get medical attention if any discomfort continues.
Rinse with water. Contact physician if discomfort continues.
5. FIRE FIGHTING MEASURES
|Extinguishing Media||Use: Foam. Carbon dioxide (CO2). Dry chemicals, sand, dolomite etc.|
|Special Fire Fighting Procedures||Use water to keep fire-exposed containers cool and disperse vapours. Water spray could be used to flush spills away from exposures and dilute spills to non-flammable mixtures. Keep run-off water out of sewers and water sources. Dike for water control.|
|Specific Hazards||If heated, volume and pressure increases strongly, resulting in explosion of container. Risk of explosion if heated. Aerosol cans may explode in fires.|
|Acrid smoke/fumes. Oxides of: Carbon.|
6. ACCIDENTAL RELEASE MEASURES
Spill Clean-up Methods
Minimize skin contact. Avoid breathing
vapours; wear appropriate respirator. Remove sources of ignition.
Keep product out of sewers and watercourses by diking or impounding. Advise authorities if product has entered or may enter sewers, watercourses or extensive land areas. Assure conformity with applicable government regulations.
Collect spillage in containers, seal securely and deliver for disposal according to local regulations. Ventilate well. Wear necessary protective equipment. Flush area with water. Do not let washing down water contaminate ponds or waterways.
7. HANDLING AND STORAGE
Avoid spilling, skin and eye contact. Keep
away from heat, sparks and open flame. Ventilate well, avoid breathing
vapours. Use approved respirator if air contamination is above accepted
level. Container must be kept tightly closed. Eye wash facilities and
emergency shower must be available when handling this product.
Keep away from heat, sparks and open flame. Store separated from: Oxidizer. Acids.
Storage of chemicals.
8. EXPOSURE CONTROLS/PERSONAL PROTECTION
|Ingredient Name||CAS No.||Reference||LT Exp 8 Hrs||ST Exp 15 Min|
|Distillates (petroleum), solvent-refined heavy paraffinic||64741-88-4||OES.||5 mg/m3||10 mg/m3|
1. Chemical resistant gloves
2. Splash proof eye goggles
Use engineering controls to reduce air
contamination to permissible
|Ventilation||No specific ventilation requirements noted, but forced ventilation could still be required if air contamination exceeds acceptable level.|
|Respirators||No specific recommendation made, but respiratory protection could still be required under exceptional circumstances when excessive air contamination exists.|
Chemical-resistant gloves required for
prolonged or repeated contact.
Wear splash proof eye goggles to prevent any possibility of eye contact.
|Other Protection||Wear appropriate clothing to prevent repeated or prolonged skin contact.|
|Hygienic Work Practices||Wash at the end of each work shift and before eating, smoking and using the toilet.|
9. PHYSICAL AND CHEMICAL PROPERTIES:
|Odour||Mild (or faint). Petroleum|
|Density (g/ml)||0.90 Temperature (oC) 16|
|Vapour Pressure||< 0.01 mmHg Temperature (oC) 20|
|Vapour Density (air=1)||> 5|
|Evaporation Rate||< 1 Reference BuAc=1|
|pH-value, conc. Solution||N/A|
|Flash Point (oC)||
246 (475 oF) Method Cd OC
(Cleveland Open Cup)
|Flammability Limit (%)||N/D – N/D|
|Solubility Description||Insoluble in water|
10. STABILITY AND REACTIVITY
|Conditions to Avoid||Avoid contact with acids and oxidizers.|
|Hazardous Decomposition Products||Oxides of: Carbon.|
|Hazardous Polymerization||Will not polymerize.|
11. TOXICOLOGICAL INFOMATION
No known information.
IARC not listed. OSHA not regulated. NTP not listed.
No known information.
No experimental toxilogical data on the preparation as such is available.
|Health Hazards, General||No specific health warnings noted.|
SKIN CONTACT. Prolonged or repeated contact
leads to drying of skin. EYE CONTACT. Irritating to eyes.
INGESTION. Could cause stomach ache or vomiting.
INHALATION. Heating can generate vapours that may cause respiratory irritation, nausea and headaches. Inhalation hazard at room temperature is unlikely due to the low volatility of this product.
|Route of Entry||Inhalation. Skin and/or eye contact. Ingestion.|
|COMPONENT:||Distillates (petroleum), solvent-refined heavy paraffinic|
|Toxic dose – LD50||N/A.|
|Toxic conc. – LC50||N/A.|
|Carcinogenicity||This petroleum base oil has been severely solvent-refined. The International Agency for Research on Cancer (IARC) has determined that there is no evidence that severely solvent-refined oils are carcinogenic to experimental animals.|
12. ECOLOGICAL INFOMATION
|Ecotoxicity||No data on possible environmental effects have been found.|
13. DISPOSAL CONSIDERATION
|Disposal Methods||Dispose of in accordance with Local Authority requirements.|
14. TRANSPORT INFORMATION:
|ROAD TRANSPORT (ADR)|
|UN Number Road||N/A|
|ADR Class||Not dangerous according to ADR.|
|SEA TRANSPORT (IMDG)|
|Sea Transport Notes||Not regulated.|
|AIR TRANSPORT (IATA/ICAO)|
|Air Transport Notes||Not regulated.|
15. REGULATORY INFORMATION:
|NL||No label required.|
|Risk Phrases||No R-phrases required.|
|Safety Phrases||No safety phrases given.|
16. OTHER INFORMATION
|Explanations of R-phrases in Section 3||No R-phrases required contains < 3% DMSO Extractable total polycyclic aromatic compound (PAC) per IP 346|
|IMPORTANT DISCLAIMER||All reasonable care has been taken to ensure that the information and advice contained herein are accurate at the time of printing. However, Oberon Manufacturing Co. accepts no tortuous or contractual liability for any loss or damages suffered as a consequence of reliance on the information and advice contained herein.|
台灣 桃園市 326-46 楊梅區民族路 5 段 201 巷 124 號
TEL : 03-4206896 FAX : 03-4202206 http:www.jingyu.biz
靖玉首頁 OBERON 目錄 STARRY 目錄