1. PRODUCT IDENTIFICATION
|Product Name :||Oberon G38|
|UN Proper Shipping Name :||None allocated|
|Other Names :||None listed|
|Product Use :||Multi Purpose E.P. Bearing Grease|
|CHEMTREC, 24-HOUR EMERGENCY TELEPHONE NUMBER|
|1-800-424-9300 (Toll-free)||For United States and Canada|
|1-703-527-3887||In the event of an incident occurring outside United States and Canada|
2. HAZARDS INDENTIFICATION
|Not regarded as a health hazard under current legislation. For further information, please refer to Section 11.|
3. COMPOSITION/INFORMATION ON INGREDIENTS
|Name||EC No.||CAS No.||Content||Symbol||R-Phrases|
|Distillates (petroleum), hydrotreated heavy naphthenic||265-155-0||64742-52-5||30-50 %||-|
|HYDROTREATED RESIDUAL OILS||265-160-8||64742-57-0||15-30 %||-|
Composition Comments Refer to Section 8 for exposure limits on ingredients.
4. FIRST AID MEASURES
Vapour inhalation under ambient conditions
is normally not a problem. If overcome by vapour from hot product,
immediately remove from source of exposure Move the exposed person to
fresh air at once. For breathing difficulties oxygen could be necessary.
Get medical attention if any discomfort continues.
DO NOT INDUCE VOMITING! Get medical attention immediately!
Remove contaminated clothing. Wash skin thoroughly with soap and water. Get medical attention if any discomfort continues.
Rinse the eye with water immediately. Continue to rinse for at least 15 minutes. Contact physician if discomfort continues.
5. FIRE FIGHTING MEASURES
|Extinguishing Media||Use: Carbon dioxide (CO2). Dry chemicals, sand, dolomite etc. Alcohol resistant foam. Water spray, fog or mist.|
|Special Firefighting Procedures||Use water to keep fire-exposed containers cool and disperse vapours. Water spray could be used to flush spills away from exposures and dilute spills to non-flammable mixtures. Avoid water in straight hose stream; will scatter and spread fire. Keep run-off water out of sewers and water sources. Dike for water control.|
|Specific Hazards||Pressure will increase in over heated, closed containers.|
|Hazardous Combustion Products||Oxides of: Carbon.|
|Protective Measures in the event of Fire||Self-contained breathing equipment and chemical resistant clothing recommended.|
6. ACCIDENTAL RELEASE MEASURES
Spill Clean-up Methods
Minimize skin contact.
Keep product out of sewers and watercourses by diking or impounding. Advise authorities if product has entered or may enter sewers, watercourses or extensive land areas. Assure conformity with applicable government regulations.
Keep all sources of ignition and hot metal surfaces away from spill. Avoid contact with eyes or skin. Place leaking containers in well ventilated area. If fire potential exists, blanket spill with foam or use water spray to disperse vapours. Contain spill to minimize contaminated area and facilitate salvage or disposal. To clean up spill, flush area sparingly with water or use absorbant material. Avoid discharge to natural water ways.
7. HANDLING AND STORAGE
Keep away from heat, sparks and open flame.
Ventilate well, avoid breathing vapours. Use approved respirator if air
contamination is above accepted level. Do not reuse container. Keep lid
closed when not in use. Do not store or mix with strong oxidizers. Avoid
spilling, skin and eye contact. Eye wash facilities and emergency shower
must be available when handling this product.
Store separate from strong acids and oxidizers. Keep away from heat, sparks and open flame.
Storage of chemicals.
8. EXPOSURE CONTROLS/PERSONAL PROTECTION
|Ingredient Name||CAS No.||Reference||LT Exp 8 Hrs||ST Exp 15 Min|
|Distillates (petroleum), hydrotreated heavy paraffinic||64742-52-5||OES.||5 mg/m3||10 mg/m3|
1. Chemical resistant gloves
2. Splash proof eye goggles
Use engineering controls to reduce air
contamination to permissible
|Ventilation||No specific ventilation requirements noted, but forced ventilation could still be required if air contamination exceeds acceptable level.|
|Respirators||No specific recommendation made, but respiratory protection could still be required under exceptional circumstances when excessive air contamination exists.|
For prolonged or repeated skin contact use
suitable protective gloves. Use protective gloves made of: Neoprene,
nitrile, polyethylene or PVC.
Wear splash proof eye goggles to prevent any possibility of eye contact.
|Other Protection||Wear appropriate clothing to prevent repeated or prolonged skin contact.|
|Hygienic Work Practices||Wash at the end of each work shift and before eating, smoking and using the toilet.|
9. PHYSICAL AND CHEMICAL PROPERTIES:
|Odour||Mild (or faint). Petroleum|
|Solubility Description||Insoluble in water|
|Solubility Value (g/100g H2O 20 oC)||< 0.1|
|Density (g/ml)||0.89 Temperature (oC) 16|
|Vapour Pressure||< 0.01 mmHg Temperature (oC) 20|
|Vapour Density (air=1)||> 5|
|Evaporation Rate||< 0.01 Reference BuAc=1|
|pH-value, conc. Solution||N/A|
|Flash Point (oC)||
246 (475 oF) Method Cd OC
(Cleveland Open Cup)
|Flammability Limit (%)||N/D – N/D|
10. STABILITY AND REACTIVITY
|Conditions to Avoid||Avoid contact with acids and oxidizers.|
|Hazardous Decomposition Products||Oxides of: Carbon.|
Will not occur.
11. TOXICOLOGICAL INFOMATION
No known information.
IARC not listed. OSHA not regulated. NTP not listed.
No known information.
No experimental toxilogical data on the preparation as such is available.
|Route of Entry||Inhalation. Skin and/or eye contact. Ingestion.|
|Medical Symptoms||MEDICAL CONDITIONS AGGRAVATED BY EXPOSURE: Not determined|
SKIN CONTACT. Prolonged or repeated contact
leads to drying of skin. EYE CONTACT. Irritating to eyes.
INGESTION. Could cause stomach ache or vomiting. Main hazard, if ingested, is aspiration into the lungs and subsequent pneumonitis.
INHALATION. Heating can generate vapours that may cause respiratory irritation, nausea and headaches. Inhalation hazard at room temperature is unlikely due to the low volatility of this product.
12. ECOLOGICAL INFOMATION
|Ecotoxicity||There is no ecological data on the product itself.|
13. DISPOSAL CONSIDERATION
|Disposal Methods||Spilled material, unused contents and empty containers must be disposed of in accordance with local, state and federal regulations.|
14. TRANSPORT INFORMATION:
|ROAD TRANSPORT (ADR)|
|UN Number Road||N/A|
|ADR Class||Not dangerous according to ADR.|
|SEA TRANSPORT (IMDG)|
|Sea Transport Notes||Not regulated.|
|AIR TRANSPORT (IATA/ICAO)|
|Air Transport Notes||Not regulated.|
15. REGULATORY INFORMATION:
|NL||No label required.|
|Risk Phrases||No R-phrases required.|
|Safety Phrases||No safety phrases given.|
16. OTHER INFORMATION
|Explanations of R-phrases in Section 3|
|IMPORTANT DISCLAIMER||All reasonable care has been taken to ensure that the information and advice contained herein are accurate at the time of printing. However, Oberon Manufacturing Co. accepts no tortuous or contractual liability for any loss or damages suffered as a consequence of reliance on the information and advice contained herein.|
台灣 桃園市 326-46 楊梅區民族路 5 段 201 巷 124 號
TEL : 03-4206896 FAX : 03-4202206 http:www.jingyu.biz
靖玉首頁 OBERON 目錄 STARRY 目錄